Tractor Talk Discussion Board |
OT: Water pump pressure switches
[ Expand ] [ View Replies ] [ Add a Reply ] [ Return to Forum ]
Posted by Dan-IA on October 29, 2006 at 11:55:38 from (66.43.223.231):
I've got this antique water pump. 1/2hp electric motor, belt, gearbox, rod going back and forth, about 4 valves with copper rings and springs. Now, I've got a pressure switch on it that turns it on when I use water and the pressure drops. Problem is, it tends to quit pumping and just keep running indefinitely. Apparently it loses its prime. Sometimes I find an air leak. Sometimes the cause is it pumped all the water out of my shallow 30-ft well, and starts sucking air. Sometimes I can't find a cause. But it would appear that just wiggling the hose up and down (forcing water through the check valve at the bottom of the well) gets it restarted without any trouble. What I need is some sort of pressure switch that works in the reverse fashion: shutting the pump off when the pressure gets too low, like say, 5psi or less. That would shut the pump down when it loses its prime, saving on the electric bill and wear/tear on the pump. Even though cavitation on this pump doesn't seem to be an issue, I still hate to see it running dry. Thanks
Replies:
Home
| Forums
Today's Featured Article -
Tractor Hydraulics - The Basics - by Curtis Von Fange. Hydraulics was one of the greatest inventions for helping man compound the work he can do. It’s amazing how a little floor jack can lift tons and tons of weight with just the flick of a handle. What’s even more amazing is that all the principals of hydraulic theory can be wrapped up in such a small package. This same package applies to any hydraulic system from the largest bulldozer to the oldest and smallest tractor. This short series will take a look at the basic layout of a simple hydraul
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
Copyright © 1997-2024 Yesterday's Tractor Co. All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V. Yesterday's Tractors - Antique Tractor HeadquartersWebsite Accessibility Policy |
|