Posted by Ron Corkum on October 16, 2008 at 13:09:32 from (71.7.157.140):
My John Deere 510 diesel blew antifreeze outside and also inside into the oil pan from overheating.I left it sit for nearly a year,drained the antifreeze and oil yesterday and removed the head today.There was only approximately a litre and a half of antifreeze to drain.The gasket was intack when I seperated it from the engine and head.I have a new head gasket ready to set in place.The minimal damage to the old gasket concerns me.Antifreeze was blown out the opposite side of the engine from the exhaust the day it overheated practically in the centre of the gasket area. Also, the 1st cylinder of the 3 cylinder diesel engine seems corroded around the top the pistion within 2 inches of the top,and the engine will not turn over at least without further cleaup and lubrication.I oiled all the surfaces when I finished the tear down until I can determine the best course of acton from here.Is this corrosion from the antifreeze or do I have something else happening here.If not, can I clean up the head,cylinder top and engine gasket surface,apply a new head gasket providing the head is straight.It looks good with the naked eye but I plan to check it with a straight edge.Bolt it all back together and start the engine? I would appreciate any help,i am not a mechanic. Thanks Ron
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Tractor Hydraulics - The Basics - by Curtis Von Fange. Hydraulics was one of the greatest inventions for helping man compound the work he can do. It’s amazing how a little floor jack can lift tons and tons of weight with just the flick of a handle. What’s even more amazing is that all the principals of hydraulic theory can be wrapped up in such a small package. This same package applies to any hydraulic system from the largest bulldozer to the oldest and smallest tractor. This short series will take a look at the basic layout of a simple hydraul
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.